Master Technician Service Conference

• 026 - "Body Seals" (October1949)

  • Every spot on the body where a seal is used to keep out dust and water. How to water test and service all body seals.

    • Volume 03 #02

• 027 -  "Valve Ups and Downs"   (November 1949)

• Explains operation of valves and camshaft. List possible causes of valve failure and corrections as well as service tips helpful in valve servicing.

  • Volume 03 #03

• 028 -  "The Straight Story on Steering"   (December 1949)

• How to track down steering difficulties. Steering gear adjustments and repairs.

  • Volume 03 #04

                             1950                                 

 

• 029 -  "Lubrication"   (January 1950)
• Volume 03 #05
• An explanation of all the types of lubricants required, and how to adequately lubricate

• 030 -  "Brake Shoe Adjustment And Alignment"   (February 1950)
• Volume 03 #06
• Explains all the factors contributing to brake noise ‹ shoe adjustments‹ alignment‹ how vibration caused by looseness results in noise.

• 031 -  "Gauge Groundwork"   (June 1950)
• Volume 03 #07
• Explains the operation and servicing procedures for the oil gauge, fuel gauge, speedometer, ammeter, etc.

• 032 - "Convertible Tops" (July 1950)
  • Volume 03 #08
  • All of the adjustments (Doors, windows and top) that can be performed on the convertible club coupe bodies.

• 033 - "Unusual Cases" (August 1950)
  • Volume 03 #09
  • Nine unusual service problems "front wheel bearings," "road splash," "clutch and brake pedal rubber seals," "carburetor air cleaner," "carburetor idle restrictions," "water pump end play," "heater defroster valve" and "carburetor accelerator pump"

• 034 - "All in a Day's Work!" (September 1950)
  • Volume 03 #10
  • A discussion of seven unusual service problems "Clutch linkage," "oil pump pressure relief valve," "oil pump discharge pipe," "left rear engine mount," "floor pan strainer," "shifting into low and reverse," and the "automatic choke."

• 035 - "Fixin' Facts" (October 1950)
  • Volume 03 #11
  • Explains the operation of the pressure-type cooling system. Also discusses factors contributing to instrument panel noises a suggestion for eliminating brake squeaks and servicing procedure for two types of deck lid locking handles.

• 036 - "Ignition System Servicing" (November 1950)
  • Volume 03 #12
  • Discusses ignition requirements of the modern high-compression engine, with special reference to the resistor-type spark plug; gives procedure for testing ignition system.

• 037 - "Hydraulic Transmission Maintenance" (December 1950)
  • Volume 04 #01, Canada Session 1
  • A detailed trouble-shooting procedure for diagnosing and correcting difficulties in the hydraulic transmission used by Dodge, DeSoto and Chrysler cars plus service information on the internal-expanding parking brake.

 

                                   1951                                  

 

• 038 - "Your New Service Plan For '51" (January 1951)
  • Volume 04 #02, Canada Session 2
  • An explanation of the new owner's service certificate, benefits to mechanics and dealers. Also, servicing tips on new car preparation, how to use the new inspection form and service coupons.

• 039 - "A Close Look at the 51's" (February 1951)
  • Volume 04 #03, Canada Session 3
  • Features of the Oriflow shock absorbers, changes in the hydraulically operated transmission, and servicing information on the automatic choke used by DeSoto and Chrysler cars.

• 040 - "Windshield Service" (March 1951)
  • Volume 04 #04, Canada Session 4
  • Service information on the new one-and-two piece type, self-locking weatherstrips. How to remove and install windshield glass, and information on the external, internal by-pass cooling systems.

• 041 - "Windshield Wipers" (April 1951)
  • Volume 04 #05, Canada Session 5
  • Up-to-the-minute trouble-shooting information on electrically and vacuum-operated windshield wiper motors. Vital facts on windshield wiper arms, blades and links.

• 042 - "The Paint Story" (May 1951)
  • Volume 04 #06, Canada Session 6
  • Interesting, helpful information on car painting, care of a car's new enamel, conditions to observe and suggestions on preserving car appearance.

• 043 - "Automotive Radio Service" (June 1951)
  • Volume 04 #07, Canada Session 7
  • Radio service suggestions that any mechanic can perform to help increase owner satisfaction. Checking a dead radio, tracing causes of radio interference, and information on installing and adjusting a radio.

• 044 - "FirePower Engine Facts" (July 1951)
  • Volume 04 #08, Canada Session 8
  • An informative, valuable discussion of the new Chrysler V-8 engine features. How to service hydraulic valve tappets, plus servicing tips on ignition and carburetor.

• 045 - "Firepower Carburetor Adjustments" (August 1951)
  • Volume 04 #09, Canada Session 9
  • Carburetor design features, diagnosis, repairs and adjustment of the various carburetor circuits. In addition, timely tips concerning the kickdown and limit switch and the dashpot.

• 046 - "Chrysler V-8 Engine Distributor" (September 1951)
  • Volume 04 #10, Canada Session 10
  • Discussion of general ignition theory plus the procedures for testing and adjusting the V-8 engine distributor. Use of scientific testing is emphasized.

• 047 - "Body Service Adjustments" (October 1951)
  • Volume 04 #11, Canada Session 11
  • Latest information available on locating water leaks and sealing the body. Hood, fender door, and decklid adjustments are also thoroughly covered.

• 048 - "Transmission, Brakes, Shock Absorber Tips" (November 1951)
  • Volume 04 #12, Canada Session 12
  • Short trouble-shooting items correcting conditions in the hydraulically operated transmission, manually operated transmission brake shoe alignment, stop light switch installation, engine mounts, and Oriflow shock absorbers.

• 049 - "Fluid - Torque Drive" (December 1951)
  • Volume 05 #01, Canada Session 13
  • An explanation of how a torque converter works. Also explains the fluid circulation in the converter system, and covers servicing the integral oil pump. This covers removal and installation operations, and diagnosis of service conditions.
    • __View the filmstrip which accompanied this booklet!!__

 

                                     1952                                 

• 050 - "Hydraulic Power Steering" (January 1952)
• Volume 05 #02, Canada Session 14
• Operation and Diagnosis. Explanation of the components of the power steering units, and how it operates. Covers diagnosis of operating conditions which can be adjusted without removing the unit from the car

• 051 - "Hydraulic Power Steering" (February 1952)
• Volume 05 #03, Canada Session 15
• Maintenance. Complete disassembly, assembly and final adjusting procedures.

• 052 - "Servicing Tips" (March 1952)
• Volume 05 #04, Canada Session 16
• A collection of five service items, with diagnosis of unusual operating conditions and their correction. Electric windshield wipers, the follow thru starter drive, improved clutch disc, clutch linkage adjustment & manifold heat control valve.

• 053 - "Automatic Overdrive" (April 1952)
• Volume 05 #05, Canada Session 17
• An explanation of power transmission through a planetary gear set; detailed operation of the overdrive unit when in direct drive and in overdrive. Explains the operation of the electrical system of the overdrive unit

• 054 - "Automatic Overdrive (controls)" (May 1952)
• Volume 05 #06, Canada Session 18
• Explains the function of each unit in the overdrive electrical system, and discusses the Control Circuit, Solenoid Circuit and Ignition Interruption Circuit in detail. Also contains trouble-shooting information applying to the electrical system.

• 055 - "Automatic Overdrive (maintenance)" (June 1952)
• Volume 05 #07, Canada Session 19
• Complete disassembly and assembly procedures applying to the overdrive unit, with service tips regarding inspection of parts.

• 056 - "Universal Joints And Propeller Shafts" (July 1952)
• Volume 05 #08, Canada Session 20
• Function of the universal joint - Both kinds. Contains tips on universal joint and propeller shaft service diagnosis, complete disassembly and assembly procedures, with lubrication information.

• 057 - "Fluid Torque Drive" (August 1952)
• Volume 05 #09, Canada Session 21
• Engine-Fed Torque Converter. This converter differs because oil supply is received from the engine oil pump. Explains the fluid circulation system, removal and installation operations, disassembly & assembly and normal service.

• 058 - "Up-To-The-Minute Service Tips" (September 1952)
• Volume 05 #10, Canada Session 22
• Diagnosis of operating conditions of the DeSoto Eight-cylinder carburetor (troubleshooting stiffness in gear shifting on the three-speed transmission) proper servicing of the car seat cushion and seat back.

• 059 - "The Red Ram V-8 Engine" (October 1952)
• Volume 05 #11, Canada Session 23
• Description of the features of the Dodge V-8 engine, with detailed information on the ignition system. Emphasizes the periods of oil changing and of oil filter service.

• 060 - "Windshield And Rear Window Service" (November 1952)
• Volume 05 #12, Canada Session 24
• Explains the types of weatherstripping used with the 1953 model one-piece windshields and rear windows. Contains complete removal and installation information. Also gives pull-type door handle removal and installation procedures.

• 061 - "1953 Body Service" (December 1952)
• Volume 06 #01, Canada Session 25
• Covers procedure for adjusting the box type & strap type door hinges, & door alignment. Also covers the steps to follow when adjusting hood and deck lid alignment. Describes the extent of the integral fender and rear quarter panel on 1953 model cars.

 

                                 1953                                      

• 062 -  "Oil And Grease Seals"  (January 1953)
• Volume 06 #02, Canada Session 26
• Describes the various types of oil and grease seals used throughout the car. Explains the precautions necessary when installing a new seal, and emphasizes the importance of using the correct seal for a specific application.

• 063 - "Steering Alignment And Gear" (February 1953)
• Volume 06 #03, Canada Session 27
• Steering irregularities traced to improper alignment of steering gear & column; adjusting hydraulically operated transmission selector levers; gasoline leakage at filler neck; sealing luggage compartment floor pan.

• 064 - "Hydraulic Tappets & Battery Performance"   (March 1953)
• Volume 06 #04, Canada Session 28
• Types of hydraulic tappets and diagnosis of operating conditions; discussion of factors affecting battery performance; announcement of a new generator pulley for Plymouth cars, to increase generator output during cold weather.

• 065 - "The Story Of Combustion" (April 1953)
• Volume 06 #05, Canada Session 29
• A detailed explanation of the composition of the fuel-air mixture used in gasoline engines. Covers the formation of products of combustion, their effect on engine performance, and measures taken to minimize acid and sludge formation in the crankcase.

• 066 - "Plymouth Hy-Drive" (May 1953)
• Volume 06 #06, Canada Session 30
• Description and operation of the engine-fed torque converter and the three-speed transmission which make up Hy-Drive. Covers maintenance operations, and tips on driving the car.

• 067 - "Electrical Fundamentals" (June 1953)
• Volume 06 #07, Canada Session 31
• The atomic theory as applied to automotive electricity. Covers the use of test ammeters and voltmeters, and recommended procedures for testing starting and generating circuits.

• 068 - "Sealing The Body" (July 1953)
• Volume 06 #08, Canada Session 32
• A discussion of the types of sealers used throughout the body to seal joints, seams and to attach rubber weatherstrips. Covers detailed procedure for testing for water and dust leaks.

• 069 - "Magnetism And Electricity" (August 1953)
• Volume 06 #09, Canada Session 33
• A fundamental explanation of magnetism and its relation to automotive electrical units. Explains the operation of the generator, starting motor, relays and solenoids, and gives testing procedures.

• 070 - "The Engine Oil Story" (September 1953)
• Volume 06 #10, Canada Session 34
• An up-to-date explanation of SAE viscosity number interpretation, with the new A.P.I. classification of oils explained in terms of selecting the proper oil for a specific operating condition.

• 071 - "Power Steering" (October 1953)
• Volume 06 #11, Canada Session 35
• A complete description of the power steering unit as used on Plymouth and Dodge cars. Explains how it works, and gives maintenance operation-s and complete diagnosis chart.
  • __View the filmstrip which accompanied this booklet!!__

• 072 - "Powerflite Automatic Transmission (Controls)" (November 1953)
  • Volume 06 #12, Canada Session 36
  • Driving instructions applicable to cars equipped with the PowerFlite transmission. Complete adjusting instructions covering the gearshift and accelerator pedal linkage, throttle pressure, and the kickdown and reverse bands.
• 073 - "Powerflite Automatic Transmission (Mechanical)" (December 1953)
• Volume 07 #01, Canada Session 37
• Explanation of the operation of the planetary gears. Gives a step-by-step build-up of the planetary gears used in the PowerFlite transmission, and traces the power flow through the transmission in the different gear ranges.

                                  1954                                    

• 074 - "Powerflite Automatic Transmission (hydraulic Operation)" (January 1954)
• Volume 07 #02, Canada Session 38
• Contains basic description of a spool valve, and how it operates. Describes the valves used in the PowerFlite transmission, and explains the oil flow through the transmission for the different gear ranges.

• 075 - "Door Alignment" (February 1954)
• Volume 07 #03, Canada Session 39
• Discusses the box-type, "L"-mounted strap type and the "U"-mounted strap-type hinges. Gives instructions for shifting hinges to correct door alignment. Also covers body shimming to correct door alignment.

• 076 - "Tires and Wheels" (March 1954)
• Volume 07 #04, Canada Session 40
• Explains the causes of tire thump, how to identify it and what to do about it. Also discusses the causes of high-speed car shake and how to correct it. Gives detailed instructions for balancing wheels and tires, and for balancing brake drums.

• 077 - "Powerflite Automatic Transmission Maintenance" (April 1954)
• Volume 07 #05, Canada Session 41
• A diagnosis presentation of irregular shift operation. Gives detailed instructions for checking hydraulic pressure line pressure, throttle pressure and governor pressure. Tells how to remove and install the governor.

• 078 - "Power Steering - coaxial type" (May 1954)
• Volume 07 #06, Canada Session 42
• Design and construction of the Coaxial-type Power Steering unit; its operation during right and left turns; lubrication instructions.

• 079 - "Airtemp Car Air Conditioning" (June 1954)
• Volume 07 #07, Canada Session 43
• Contains an explanation of the principles of air conditioning, and describes the application of the system units to the automobile. Gives diagnosis and maintenance procedures.

• 080 - "Power Brakes" (July 1954)
• Volume 07 #08, Canada Session 44
• Explains the construction and operation of the power brake unit. Contains service diagnosis and repair procedure.
  • __View the filmstrip which accompanied this booklet!!

• 081 - "Pre - Ignition And Detonation" (August 1954)
• Volume 07 #09, Canada Session 45
• Discusses differences between pre-ignition & detonation, explains the causes of each condition. Emphasizes importance of spark plug selection, & the importance of ignition timing and its relation to inaudible pre-ignition.

• 082 - "Automatic Choke And Heat Control Valve" (September 1954)
• Volume 07 #10, Canada Session 46
• Detailed description of the integral type automatic choke, its operation and maintenance, as used with the V-8 engines. Also contains description, operation and maintenance of the manifold heat control valve.

• 083 - "Hydraulic Tappet Service" (October 1954)
• Volume 07 #11, Canada Session 47
• Describes the construction and operation of the hydraulic valve tappet as used in the V-8 engines. Covers diagnosis of operating conditions, and importance of engine lubrication

• 084 - "Service Tips For 1955" (November 1954)
• Volume 07 #12, Canada Session 48
• Describes new features of the 1955 models, with maintenance & adjustment for door handles, transmission lever linkage, clutch & brake pedals, door hinges & rear deck lid torsion bar. Also gives puncture repair procedure for tubeless tires.

• 085 - "Windshield and Headling Service" (December 1954)
• Volume 08 #01, Canada Session 49
• Covers instructions for removal and installation of the curved windshield and rear window, with illustrations of the sections of chrome moldings. Also covers removal and installation instructions applying to the replacement of headlining.

 

 

                                  1955                                  

 

• 086 - "The Four-barrel Carburetor" (January 1955)
• Volume 08 #02, Canada Session 50
• Contains description of the systems of the four-barrel carburetor, operation of the throttle valves and the automatic choke linkage. Also, complete instructions for the adjustment of float level, metering rods, choke unloader and engine idle speed.

• 087 - "Servicing The 1955 Coaxial Power Steering Unit" (February 1955)
• Volume 08 #03, Canada Session 51
• In addition to complete instructions for adjusting backlash, worm shaft bearings and the control valve, this book outlines the procedures necessary for the replacement of all oil seals and "O" rings

• 088 - "1955 Body Service Suggestions" (March 1955)
• Volume 08 #04, Canada Session 52
• Explains procedures for adjusting the rear quarter windows of the two-door hard-top body models. Also gives instructions for aligning the convertible top, explaining the adjusting points provided for this purpose.

• 089 - "Powerflite Transmission Maintenance  Upshift Pattern" (April 1955)
• Volume 08 #05, Canada Session 53
• A diagnosis-type presentation of conditions affecting smooth upshift performance. Covers procedures for setting engine normal and fast-idle speeds, testing and adjusting hydraulic pressures, and adjusting the kickdown and reverse bands.

• 090 - "Powerflite Transmission Maintenance ‹ Downshift Pattern" (May 1955)
• Volume 08 #06, Canada Session 54
• A companion book to Session 89, covering those conditions which affect smooth downshift performance. Gives a detailed explanation of the function of the servo restrictor valve, and instructions for correcting the downshift pattern.

• 091 - "Body Sealing Tips" (June 1955)
• Volume 08 #07, Canada Session 55
• An interesting study of sealing the body against water and dust leaks. Special information on the flipper over the door of two-door hard-top models, cars equipped with power-operated window lifts, etc.

• 092 - "Beauty -- Inside and Out" (July 1955)
• Volume 08 #08, Canada Session 56
• A complete story on the subject of upholstery cleaning, with reference to the types of upholstery materials and their reactions to cleaning agents. Contains a ready reference chart of types of stains, methods of cleaning and the cleaning agent to use.

• 093 - "Keeping Your Customers Cool" (August 1955)
• Volume 08 #09, Canada Session 57
• Contains a description of the standard air conditioning system how it works and the function of each unit in the system. Contains a diagnosis and maintenance section to cover everyday operating conditions.

• 094 - "The V-8 Pressure Cooling System" (September 1955)
• Volume 08 #10, Canada Session 58
• Contains a description of the engine cooling system as applied to the V-8 engine with special reference to the pressure cap and thermostat. Also has a table of cooling system capacities and amount of anti-freeze needed for varying degrees

• 095 - "Powerflite, Power Steering, Carburetor and Fuel Gauge Service" (October 1955)
• Volume 08 #11, Canada Session 59
• A general trouble-shooting coverage of unusual operating conditions affecting the above units.
  • __View the filmstrip which accompanied this booklet!!
• 096 - "The Center - Plane Brake" (November 1955)
• Volume 08 #12, Canada Session 60
• Contains construction and operation description of the new center-plane brake with adjusting instructions. Also contains diagnosis and corrective procedures applying to the fixed-anchor type of brake

• 097 - "The 12-volt Electrical System & Powerflite Push - Button Control" (December 1955)
• Volume 09 #01, Canada Session 61

 

                                  1956                                    

 

• 098 - "Door & Window Adjustments - 1956 Models" (January 1956)
• Volume 09 #02, Canada Session 62
• 4-door hardtop

• 099 - "The Three - Speed Automatic Transmission" (February 1956)
• Volume 09 #03, Canada Session 63
• Read the instructional booklet
• The awesome new Torqueflite - applies to all '56-64 push-button-operated Mopars - Gives all sorts of very useful tips for adjusting linkages and cables, and the theory behind operation.
• 100 - "New Plymouth 277 - Cubic - Inch V-8 Engine" (March 1956)
• Volume 09 #04, Canada Session 64
  • __View the filmstrip which accompanied this booklet!!

• 101 - "Latest Tips On Powerflite & Power Steering Service" (April 1956)
• Volume 09 #05, Canada Session 65

• 102 - "Carburetor Service" (May 1956)
• Volume 09 #06, Canada Session 66
• Factors affecting smooth idle, troubleshooting the problems.

• 103 - "Vibration Diagnosis"   (June 1956)
• Volume 09 #07, Canada Session 67
  • A great source for understanding the nature of automotive vibrations, how to conduct a test to pinpoint their causes and outlines some of the corrective steps to take.  This is a great booklet to read and understand the difference between chassis vibrations and engine vibrations in Chrysler products.

• 104 - "Air Conditioning Service" (July 1956)
• Volume 09 #08, Canada Session 68
• Standard & deluxe units

• 105 - "Powerflite, Steering and Brake Service" (August 1956)
• Volume 09 #09, Canada Session 69
  • __View the filmstrip which accompanied this booklet!!

• 106 - "Heater And Defroster Service" (September 1956)
• Volume 09 #10, Canada Session 70
• Gas heater

• 107 - "New Features Of The 1957 Cars" (October 1956)
• Volume 09 #11, Canada Session 71

• 108 - "Glass And Door Service" (November 1956)
• Volume 09 #12, Canada Session 72
  • If you're wondering about how to replace one of the Full-View Wrap-Around windshields, or the rear window, there's good news for you. If anything, it's easier done than ever before!
  • Door lock and glass adjustments are easier than you think with this nifty step-by-step guide.
• 109 - "Service Tips On 1957 Cars" (December 1956)
• Volume 10 #01, Canada Session 73

 

                                  1957                                    

• 110 - "Door Adjustments - 1957 Adjustments" (January 1957)
• Volume 10 #02, Canada Session 74
• Imperial curved glass

• 111 - "Body Sealing - '57 Cars" (February 1957)
• Volume 10 #03, Canada Session 75

• 112 - "Sleeve - Type Power Steering Pump & Total- Contact Brakes" (March 1957)
• Volume 10 #04, Canada Session 76

• 113 - "Torque-Flite Transmission Service" (April 1957)
• Volume 10 #05, Canada Session 77
  • __View the filmstrip which accompanied this booklet!!
• 114 - "1957 Air Conditioning Service" (May 1957)
• Volume 10 #06, Canada Session 78
• 115 - "Propeller Shaft And Universal Joint Service" (June 1957)
• Volume 10 #07, Canada Session 79

• 116 - "Suburban Body Service Tips" (July 1957)
• Volume 10 #08, Canada Session 80

• 117 - "Hardtop Adjustments -- Windows & Locks" (August1957)
• Volume 10 #09, Canada Session 81

• 118 - "Automotive Electricity" (September 1957)
• Volume 10 #10, Canada Session 82
  • You see... Water and electricity are quite a bit alike. They both need some means of carrying them from where they're produced to the place in which they're used. In a water system, pipes do the carrying. In an electrical system, wires take over the carrying job.
  • With this growing increase in automotive electricity, there's a growing need for us to be up on electrical maintenance. Knowing your way around each new circuit, then, is your best bet to stay high in our service customers' favor.
  • Be sure to check out a genuine Score Card from Session 118:    front  &   back
• 119 - "A Look At 1958 Car Features"(October 1957)
• Volume 10 #11, Canada Session 83
  • This preview of the 1958 model features will acquaint you with some of the new units we'll be talking more about during the coming months. The more easily you'll understand diagnosis and maintenance procedures coming your way later.
  • Although this guide is damaged and two pages are missing, it provides valuable information on this landmark year.
• 120 - "Constant - Control Power Steering" (November 1957)
• Volume 10 #12, Canada Session 84
  • New for 1958, The Constant-Control Power Steering Unit provides postive "feel-of-the-road".
  • Although damaged, this guides provides valuable information on the operation and adjustment of this steering control used on Imperials through the 1960's.

• 121 - "The New AFB Carburetor" (December 1957)
• Volume 11 #01

 

                                  1958                                    

• 122 - "Sure-Grip Differential" (January 1958)
• Volume 11 #02
• precautions on balancing rear wheels

• 123 - "Air - Conditioning Service - 1958" (February 1958)
• Volume 11 #03

• 124 - "Transmission Maintenance" (March 1958)
• Volume 11 #04
• Manual/Automatic

• 125 - "Brake Service - 1958" (April 1958)
• Volume 11 #05
  • __View the filmstrip which accompanied this booklet!

• 126 - "Power Steering And Carburetor Service" (May 1958)
• Volume 11 #06
• Carburetor service, Engine cooling, Sure-grip differential

• 127 - "Electrical Tests" (June 1958)
• Volume 11 #07

• 128 - "Long Trip Get-Ready Service" (July 1958)
• Volume 11 #08
• Dual headlight aiming, Auto-pilot service

• 129 - "Torqueflite Service Tips" (August 1958)
• Volume 11 #09

• 130 - "1959 Model Features" (September 1958)
• Volume 11 #10
• The wall calendar has some GREAT pictures of all of the 1959 cars

• 131 - "New Car Predelivery Service" (October 1958)
• Volume 11 #11

• 132 - "1959 Car Heating Systems" (November 1958)
• Volume 11 #12

• 133 - "Front & Rear Suspension Service" (December 1958)
• Volume 12 #01
  • Proper Front & Rear Suspension adjustment affects handling, ride, safe braking and tire wear.
  • Although this guide is badly damaged, it contains valuable information on the suspension of Chrysler automobiles.
   

                                    1959                                    

 

• 134 - "Service Tips on Swivel & Power Seats" (January 1959)
• Volume 12 #02
  • __View the filmstrip which accompanied this booklet!!

• 135 - "Fixin' Facts On Electrical Accessories" (February 1959)
• Volume 12 #03
• Three of the most popular accessories on 1959 cars are the transistor-powered Radio, the automatic beam changer, the automatic beam changer, and the Mirror-Matic mirror.
•  

• 136 - "The New Distributor - Built By Chrysler Corporation" (March 1959)
• Volume 12 #04
• Aluminum housing

• 137 - "1959 - Air Conditioning Service" (April 1959)
• Volume 12 #05

• 138 - "The New 3 - Platform Brakes" (May 1959)
• Volume 12 #06
  • New for 1960, 3-Platform brakes are quite different from previous brakes. This guide will step you through the installation and repair of these important safety features.

• 139 - "Summer Tune-up Tips" (June 1959)
• Volume 12 #07
• LOTS!

• 140 - "New Torqueflite Transmission" (July 1959)
• Volume 12 #08

• 141 - "Piston Ring Service" (August 1959)
• Volume 12 #09
• Engine assembly tips

• 142 - "Valve & Bearing Service" (September 1959)
• Volume 12 #10

• 143 - "Features Of The 1960 P-series Models" (October 1959)
• Volume 12 #11
  • __View the filmstrip which accompanied this booklet!!

• 144 - "The New 6-Cylinder OHV Engine" (November 1959)
• Volume 12 #12

• 145 - "The A-904 Torqueflite Automatic Transmission" (December 1959)
• Volume 13 #01
• (FOR 6-CYLINDER ENGINES)

 

 

                                   1960                                        

• 146 - "Suspension And Front-end Alignment Features - 1960 Models" (January 1960)
• Volume 13 #02
• for new 1960 models
  • __View the filmstrip which accompanied this booklet!!

• 147 - "Ram Induction Fuel System And Valiant Brakes" (February 1960)
• Volume 13 #03

• 148 - "Alternator Service" (March 1960)
• Volume 13 #04

• 149 -  "The Holley Four-Barrel Carburetor Story"  (April 1960)
• Volume 13 #05
• 150 - "Doors, Locks and Windows Service" (May 1960)
• Volume 13 #06
  • __View the filmstrip which accompanied this booklet!!

• 151 -  "Steering Service Tips for 1960"  (June 1960)
• Volume 13 #07
  • __View the filmstrip which accompanied this booklet!!

• 152 -  "Suburban and Convertible Body Service"  (July 1960)
• Volume 13 #08
  •      View the filmstrip which accompanied this booklet!!

• 153 -  "Brake System Service"  (August 1960)
• Volume 13 #09
• Parking brake
• __View the filmstrip which accompanied this booklet!!

• 154 - "Features of the 1961 Models" (September 1960)
• Volume 13 #10
  •      View the filmstrip which accompanied this booklet!!
• 155 - "Instrument Panel Service" (October 1960)
• Volume 13 #11
  • __View the filmstrip which accompanied this booklet!!

• 156 - "Cold-weather Operation" (November 1960)
• Volume 13 #12

• 157 - "Servicing Operating Controls" (December 1960)
• Volume 14 #01
• Throttle, clutch, power steering, parking brake
  • __View the filmstrip which accompanied this booklet!!

 

 

                                  1961                                 

• 158 - "Engine Service Tips" (January 1961)
• Volume 14 #02
  • This reference book provides field-tested answers that eliminate guesswork and needless loss when you are called upon to correct certain engine conditions. It tells you what to do, and how and when to do it, to get the best engine performance.

• 159 - "Steering and Suspension Service Tips" (February 1961)
• Volume 14 #03

---

Announcing a Fresh, New Look...
for the Master Technicians Service Conference

Introducing the larger-format MTSC books and a new award program!
 

---

• 160 - "Air-Conditioning Diagnosis" (March 1961)
• Volume 14 #04
  • __View the filmstrip which accompanied this booklet!!

• 161 - "Total-Contact Brake Service Tips" (April 1961)
• Volume 14 #05

• 162 - "Engine Oil Control" (May 1961)
• Volume 14 #06

• 163 - "Body Service Adjustments" (June 1961)
• Volume 14 #07

• 164 - "The Boss of Main Street" (July 1961)
• Volume 14 #08

• 165 - "Manual Transmission Service" (August 1961)
• Volume 14 #09

• 166 - "What's New for '62" (September 1961)
• Volume 14 #10

• 167 - "Brake and Transmission Service Tips" (October 1961)
• Volume 14 #11

• 168 - "Electrical Circuit Diagnosis" (November 1961)
• Volume 14 #12

• 169 -  "Alternator And Cranking Motor" (December 1961)
• Volume 15 #1

 

                                    1962                                   

 

• 170 -  "Seasonal Service Suggestions"       (January 1962)
• Volume 15 #2

• 171 -  "Body Service Clinic"       (February 1962)
• Volume 15 #3

• 172 -  "Steering Geometry and Gears"       (March 1962)
• Volume 15 #4

• 173 -  "Countdown 4 Safety" (April 1962)
• Volume 15 #5

• 174 -  "Air-Conditioned Car Comfort" (May 1962)
• Volume 15 #6

• 175 -  "The Master Touch" (June 1962)
• Volume 15 #7

• 176 -  "Torqueflite Diagnosis" (July 1962)
• Volume 15 #8

• 177 -  "The Extra Pinch" (August1962)
• Volume 15 #9

• 178 - (September 1962)
• Volume 15 #10

• 179 - (October 1962)
• Volume 15 #11

• 180 - (November 1962)
• Volume 15 #12

• 181 - (December 1962)
• Volume 15 #13

 

                                    1963                                   

 

• 182 - "1963 Model Preview" (January 1963)
• Volume 63 #01

• 183 - "Heater Service Tips" (February 1963)
• Volume 63 #02
  • __View the filmstrip which accompanied this booklet!!

• 184 - "Fundamentals of Electricity and Magnetism" (March 1963)
• Volume 63 #03
  • __View the filmstrip which accompanied this booklet!!

• 185 - "Electrical Diagnosis" (April 1963)
• Volume 63 #04
  • __View the filmstrip which accompanied this booklet!!

• 186 - "Lubrication Service" (May 1963)
• Volume 63 #05

• 187 - "Servo-Contact Brake Service" (June 1963)
• Volume 63 #06

• 188 - "Carburetion and Performance Diagnosis" (July 1963)
• Volume 63 #07

• 189 - "Valiant & Dart Rear Axle Service" (August 1963)
• Volume 63 #08

• 190 - (September 1963)
• Volume 63 #09

• 191 - "Heavy Duty Options" (October 1963)
• Volume 63 #10

• 192 - "1963 Model Service Digest" (November 1963)
• Volume 63 #11

• 193 - "Customer Care" (December 1963)
• Volume 63 #12

   

                                    1964                                    

   

• 194 - "What's In Store For 1964"   (January 1964)
• Volume 64 #01

• 195 - "Pre-Delivery Inspection"   (February 1964)
• Volume 64 #02

• 196 - "Body Service Tips"   (March 1964)
• Volume 64 #03

• 197 - "Hydraulics Fundamentals"   (April 1964)
• Volume 64 #04

• 198 - "Torqueflite Hydraulics"   (May 1964)
• Volume 64 #05
• The Meeting Guide is available for this issue!
•      View the filmstrip which accompanied this booklet!!

• 199 - "